PRE-RELEASE

30 02 599 Cleaning agent

30 02 599 Cleaning agent

Specifications

Loctite Super Clean 7063. 150 ml spray can.

Saab application

Cleaning agent for most materials to be glued with Loctite anaerobic products, such as thread locker, thread sealant and products for mounting bushings.

Packaging

1

Transport

The product is classified as dangerous goods when transporting. Special regulations apply to packaging, marking and transport, therefore existing lead times cannot be guaranteed.

Directives

The product is extremely flammable. Dehydrates the skin. May be hazardous if inhaled after frequent and repeated exposure. Pressurized can. Must not be exposed to direct sunlight or temperatures above +50 ° C. Must not be punctured or burned. Also applies to empty can. Do not spray toward open flame or glowing materials. Must be stored separately from materials which may ignite the product - Smoking is prohibited. Avoid inhalation of spray mist. Make sure ventilation is adequate.

Material safety data sheet

1.	IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING Product code 0178313 Product name 7063 Manufacturer - supplier Loctite Sweden AB Box 8823 SE-402 71 GÖTEBORG Tel: +46 31 7505400 Fax: +46 31 7505391 Tel (emergencies): +353-1-4599301 / +353-87-2629625 / +353-1-4046444

2.

COMPOSITION/INFORMATION ON INGREDIENTS Product type Solvent-based cleaner Ingredient CAS-no. Conc. R-phrases Classification Dimethoxymethane 109-87-5 10.00 - 30.00 R11 F Aliphatic hydrocarbon solvent 64742-49-0 60.00 - 80.00 R11, R65, R51/53 Xn, F, N Ethanol, denatured 64-17-5 10.00 - 30.00 R11 F Key FB/FH/FM = Hazard code for fire/health/environment T+ = Very toxic T = Toxic C = Corrosive Xn = Harmful Xi = Irritant V = Moderately harmful IK = Not subject to labelling E = Explosive O = Oxidizing F+ = Extremely flammable F = Highly flammable N = Dangerous for the environment

3.	HAZARDS IDENTIFICATION This product is highly flammable. Harmful: may cause lung damage if swallowed. The solvent defats the skin and may cause cracking and, in the event of repeated contact, eczema. Vapours may cause head aches and nausea.

4.

FIRST AID MEASURES Inhalation Remove affected person to fresh air, and if still feeling unwell seek medical attention. Skin Wash skin with plenty of soap and water and apply replenishing cream. Eyes Flush eyes immediately with plenty of water for at least 15 minutes. Seek medical attention immediately. Ingestion Rinse mouth with water then give plenty of water to drink. Do not induce vomiting. Seek medical advice.

5.

FIRE-FIGHTING MEASURES Fire/Explosions risks This product is highly flammable having a flash point of -21°C. Keep unaffected containers cool with water spray. Suitable extinguishing media If product is involved in fire extinguish with dry powder, foam or carbon dioxide. Protective equipment Self-contained breathing apparatus should be worn when dealing with fire.

6.	SPILLAGE/ACCIDENTAL RELEASE MEASURES Personal precautions Ventilate area. Eliminate sources of ignition. Methods for cleaning up Confine the spillage with sand, earth or the like, and place in a closed container, which should be partially filled (air space), for disposal.

7.

HANDLING AND STORAGE Advice for safe handling Use in well ventilated area. Keep away from sources of ignition - no smoking. Vapours should be extracted to avoid inhalation. Prolonged or repeated skin contact should be avoided. Storage instructions Keep away from sources of ignition. No smoking. Store away from heat in a cool, well-ventilated area.

8.

EXPOSURE CONTROLS/PERSONAL PROTECTION Occupational exposure limits. Chemical identity Limit value (SE) Ethanol, denatured NGV 500ppm 8h TWA. KTV 1000ppm (1900mg/m3) 15min Skin protection In case of repeated or prolonged skin contact, wear suitable gloves made of PVC, polyethene, natural rubber or similar ester-resistant material. Other information Use only in well-ventilated areas.

9.	PHYSICAL AND CHEMICAL PROPERTIES Form/state Liquid Odour Hydrocarbon Colour Clear, Colourless Flash Point (PMCC) -21°C Solubility in water Insoluble Solubility in acetone Miscible Density 0.735 kg/m³ Boiling point 87 to 104°C Vapour pressure Less than 1.75 bar at 50°C

10.	STABILITY AND REACTIVITY Stability Relatively stable under recommended conditions of storage and handling. Non-reactive with Oxidizing agents, except for peroxides.

11.

TOXICOLOGICAL INFORMATION Inhalation Inhalation of vapours may cause headaches or nausea. Skin Acute dermal LD50 (rabbit) is estimated to be >2000mg/kg. Solvent may remove essential oils from the skin making it susceptible to attack from other chemicals. Eyes May cause irritation to the eyes. Ingestion Small amounts of liquid aspirated into the respiratory system during ingestion or from vomiting may cause bronchopneumonia or pulmonary oedema. Ingestion of large quantities may cause liver or kidney damage.

12.	ECOLOGICAL INFORMATION Ecotoxicity Does not contain any substances listed on the Montreal protocol.

13.	DISPOSAL CONSIDERATIONS Disposal considerations Dispose of in accordance with local and national regulations. Evaporation and incineration recommended.

14.	TRANSPORT INFORMATION UN-no. 1993 Air (IATA) Flammable liquid, n.o.s. Class 3, Pkg. Grp. II. Sea (IMO) Flammable liquid, Class 3.1, Pkg. Grp. II. EmS 3-07. MFAG 310. Road/Rail (ADR/RID) Flammable liquid, n.o.s., Class 3, Item no.2°(b), label no. 3.

15.

REGULATORY INFORMATION Contains Naphtha Hazard class Highly flammable Harmful R-phrases R11 Highly Flammable. R65 Harmful: may cause lung damage if swallowed. S-phases S9 Keep container in a well-ventilated place. S23 Do not breathe vapours. S33 Take precautionary measures against static discharges. S62 If swallowed do not induce vomiting: seek medical advice immediately and show this container or label.

16.

OTHER INFORMATION The information in this material safety data sheet was obtained from reputable sources and to the best of our knowledge is accurate and current at the mentioned date. Neither Loctite nor its subsidiary companies accept any liability arising out of the use of the information provided here or the use, application or processing of the product(s) described herein. Attention of users is drawn to the possible hazards from improper use of the product(s). Material safety data sheet revised 2000-01-31 For more information Loctite Corporation, International Health and Regulatory Affairs, Tallaght Business Park, Whitestown, Dublin 24, Ireland. Tel: +353-1-4046444 Fax: +353-1-4510806 Produced by Dr. Sandra Wade Senior HRA Specialist Health & Regulatory Affairs - Europe

PRE-RELEASE

---

---

This project is supported by memberships and donations. If you use this site, please consider Joining SCNA and/or making a donation.