30 08 604 Clean dry lubricating film
|
|
30 08 604 Clean dry lubricating film
|
Gleitmo 300. Silicone wax. Colourless. Free of oil and grease. 400 ml spray can.
Invisible lubricating film for lubricating seat belts, rubber, plastic and interior parts.
1
The product is classified as dangerous goods when transporting. Special regulations apply to packaging, marking and transport, therefore existing lead times cannot be guaranteed.
The product is extremely flammable. May be hazardous if inhaled after frequent and repeated exposure. May be hazardous to skin in case of prolonged exposure. Pressurized can. Must not be exposed to direct sunlight or temperatures above +50
°
C. Must not be punctured or burned. Also applies to empty can. Do not spray toward open flame or glowing materials. Must be stored separately from materials which may ignite the product - Smoking is prohibited. Avoid inhaling spray mist. Avoid skin and eye contact. Make sure that ventilation is adequate.
|
Material safety data sheet/
|
|
1.
|
IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING
Product name
|
Gleitmo 300 Spray
|
Chemical name
|
Silicon wax in naphtha with additive.
|
Part no.
|
fl0689
|
Manufacturer - supplier
|
Gleitmo Technik AB
Varlabergsvägen 6
434 91 KUNGSBACKA
Tel: +46 300 333 33
Emergencies: 112
|
Application
|
Colourless dry lubricant for textiles etc.
|
|
|
2.
|
COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient
|
CAS-no.
|
Content (%)
|
FM
|
FB
|
FH
|
R-phrases
|
Aliphatic naphtha, light
|
64742-49-0
|
30 - 60
|
|
F+
|
Xn
|
11-65
|
Isopropanol
|
67-63-0
|
1 - 5
|
|
F
|
V
|
313-322-320-11
|
Propane
|
74-98-6
|
10-30
|
|
|
|
|
Butane
|
106-97-8
|
10-30
|
|
|
|
|
Key
|
FB/FH/FM = Hazard code for fire/health/environment
T+ = Very toxic
T = Toxic
C = Corrosive
Xn = Harmful
Xi = Irritant
V = Moderately harmful
IK = Not subject to labelling
E = Explosive
O = Oxidizing
F+ = Extremely flammable
F = Highly flammable
N = Dangerous for the environment
|
|
|
3.
|
HAZARDS IDENTIFICATION
Highly flammable. The product can produce vapours that can form a flammable mixture with air at temperatures close to or above the flash point. Heating may cause the container to explode. Defats the skin. Inhalation of high vapour concentrations may have narcotic effect.
|
|
4.
|
FIRST AID MEASURES
Other information
|
Take off contaminated clothing immediately.
|
Inhalation
|
Fresh air, warmth and rest. Seek medical advice.
|
Skin
|
Wash skin immediately with soap and water. Moisturize with suitable skin cream. In case of skin irritation, seek medical advice.
|
Eyes
|
Rinse the eyes for a long time with plenty of water. Seek medical treatment. Hold the eyelids wide apart.
|
|
|
5.
|
FIRE-FIGHTING MEASURES
Suitable extinguishing media
|
Water mist, foam or carbon dioxide.
|
Unsuitable extinguishing media
|
Water jet.
|
Fire/explosions risks
|
Can produce explosive mixture with air. Aerosol cans can explode in fire.
|
Special protective equipment for firefighters
|
Complete protective equipment including respiratory equipment.
|
Other information
|
Do not breathe fumes from the fire. Move containers in the vicinity of the fire immediately or cool with water.
|
|
|
6.
|
SPILLAGE/ACCIDENTAL RELEASE MEASURES
Personal precautions
|
Do not breathe vapours. Avoid contact with skin and eyes. Use the prescribed protective equipment.
|
Environmental precautions
|
Keep the product away from drains, the ground and watercourses. Contact the appropriate authority immediately if the product enters drains, lakes or watercourses.
|
Methods for cleaning up
|
Absorb with appropriate absorbent material or collect and deliver to the closest disposal station. Dispose as described under heading 13.
|
Other information
|
Risk of explosion. Remove all sources of ignition. Ventilate well. Keep unauthorized persons away from the spillage.
|
|
|
7.
|
HANDLING AND STORAGE
Special properties and risks
|
The vapours are heavier than air and collect at floor level and low-lying areas. Flammable vapours that can combine with air to form an explosive mixture are produce at temperatures far below room temperature.
|
Advice for safe handling
|
Avoid contact with eyes, skin and clothes. Do not breathe vapours. Use only in well-ventilated areas. Store away from direct sunlight, heat, fire and other sources of ignition. Take precautionary measures against static discharges.
|
Storage instructions
|
Store in a dry, well-ventilated place. Keep away from fire and direct sunlight. No smoking. Keep cool and dry, away from food, drink and animal feeding stuffs. Pressurized container: do not expose to temperatures exceeding 50ºC. Heating may cause the container to explode. Store indoors. Avoid cooling below 0ºC.
|
|
|
8.
|
EXPOSURE CONTROLS/PERSONAL PROTECTION
Chemical identity
|
Limit
|
Aliphatic naphtha, light
|
350 mg/m
3
|
Control procedures
|
Use only in well-ventilated areas. Do not smoke, drink or eat when using the product. Good personal hygiene is essential. Wash hands before taking a break and on completion of the work. Wash contaminated clothing before it is used again. The use of a barrier cream is recommended.
|
Respiratory equipment
|
A full-face or half-face mask with filter for organic vapours must be used in case of high vapour concentrations or if ventilation is inadequate.
|
Eye protection
|
Close-fitting protective glasses with side shields.
|
Protective gloves
|
Standard gloves.
|
Skin and body protection
|
Work clothes.
|
|
|
9.
|
PHYSICAL AND CHEMICAL PROPERTIES
Form/state
|
Aerosol
|
Odour
|
Mild odour of hydrocarbons
|
Colour
|
Colourless
|
Solubility
|
Soluble in organic solvents
|
Melting point
|
-150°C (naphtha)
|
Vapour pressure
|
240 hPa at +20°C
|
Density
|
1.0 g/cm³
|
Explosion limits
|
0.8 vol % - 8 vol %
|
Solubility in water
|
Insoluble
|
Autoignition point
|
+260°C (naphtha)
|
Boiling point
|
+57-63°C (naphtha)
|
Flash point
|
-33°C
|
|
|
10.
|
STABILITY AND REACTIVITY
Stability
|
Vapours can form an explosive mixture with air. Heating above 50ºC may cause the container to explode.
|
Reacts with
|
Reacts with strong oxidizing agents.
|
Hazardous decomposition products
|
None if guidelines are followed.
|
|
|
11.
|
TOXICOLOGICAL INFORMATION
Inhalation
|
Irritating to mucus membranes. May cause headaches and dizziness.
|
Skin
|
Frequent or prolonged contact may defat the skin and produce discomfort and dermatitis.
|
Eyes
|
Irritating to eyes.
|
Ingestion
|
If swallowed, may cause stinging in mouth and throat, nausea and stomach pains. Chemically-induced pneumonia may result from the product entering the lungs due to ingestion or in particular vomiting.
|
LD50 Oral
|
> 2000 mg/kg (naphtha) rat.
|
LD50 Dermal
|
> 2000 mg/kg (naphtha) rat.
|
LC50 Inhalation
|
>190 ml/1/4 hrs LD50, rat.
|
|
|
12.
|
ECOLOGICAL INFORMATION
Ecotoxicity
|
Very toxic for aquatic organisms, may cause long-term adverse effects in the aquatic environment.
|
Other information
|
Do not empty into sewers or drains.
|
|
|
13.
|
DISPOSAL CONSIDERATIONS
Disposal considerations
|
Dispose of product waste as hazardous waste in accordance with regulations. Containers that are completely empty (including propellant) can be sorted as metal containers for recycling.
|
|
|
14.
|
TRANSPORT INFORMATION
Road (ADR)
|
UN-no.:
1950
Hazardous goods
Marg no.
|
Class:
2
|
Label
Hazard no.
|
Rail (RID)
|
UN-no.:
1950
|
Class:
2
|
Label
Hazard no.
|
Sea (IMDG)
|
UN-no.:
1950
Hazardous goods
Class:
2.1
EmS:
2-13
|
Page
MFAG:
311
Label
Marine poll:
No
|
Sub. Risk
Package group
|
Air (IATA)
|
UN-no.:
1950
|
Class:
2.1
|
Label
|
Proper shipping name
|
Aerosols, flammable.
|
Other transport information
|
Keep away from food stuffs. Keep away from sources of heat. Storage temperature max. +50ºC. Forbidden to send by post.
|
|
|
15.
|
REGULATORY INFORMATION
Pressurized container
|
Protect from sunlight and do not expose to temperatures above 50°C. Do not pierce or burn, even after use. Do not spray near a naked flame or any incandescent material.
|
R-phrases
|
R12
|
Extremely flammable.
|
|
|
R18
|
A flammable/explosive vapour-air mixture can form during use.
|
|
|
R51/53
|
Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
|
|
|
R66
|
Repeated exposure may cause skin dryness or cracking.
|
|
|
R67
|
Vapours may cause drowsiness and dizziness.
|
S-phases
|
S2
|
Keep out of the reach of children.
|
|
|
S9
|
Keep container in a well-ventilated place.
|
|
|
S16
|
Keep away from sources of ignition - No smoking.
|
|
|
S23
|
Do not breathe gas/fumes/vapour/spray (appropriate wording to be specified by the manufacturer).
|
|
|
S24/25
|
Avoid contact with skin and eyes.
|
|
|
S51
|
Use only in well-ventilated areas.
|
|
|
16.
|
OTHER INFORMATION
General information
|
This material safety data sheet is only intended to provide guidance as to safe handling with regard to health, safety and the environment. The information contained in this material safety data sheet is not a specification of the product and must not be considered as a guarantee of any specific properties.
|
Drafted by
|
Sven Berlander
|
Issued
|
2000-03-20
|
|
