SAAB WIS ONLINE

PRE-RELEASE

30 15 948 Cavity fluid

30 15 948 Cavity fluid


Specifications

Teroson Terotex HV 200 Extra T108. Wax-based cavity fluid with anti-corrosion additive, high penetrating capacity. 500 ml spray can.

Packaging

1

Transport

The product is classified as dangerous goods when transporting. Special regulations apply to packaging, marking and transport, therefore existing lead times cannot be guaranteed.

Directives

The product is highly flammable. May be hazardous if inhaled after frequent and repeated exposure. May be harmful if ingested. Dehydrates skin. Pressurised can. Must not be exposed to direct sunlight or temperatures above +50°C. Must not be punctured or burned. Also applies to empty can. Do not spray toward open flame or hot materials. Must be stored separately from materials which may ignite the product - Smoking is prohibited. Avoid inhaling spray mist. Provide adequate ventilation.

Product data sheet


1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING

Product name Teroson cavity protection (T108)
Application Cavity protection
Manufacturer - supplier Loctite Sweden AB Automotive Aftermarket P.O. Box 8823 SE-402 71 GÖTEBORG Tel: +46 31 750 54 00


2. COMPOSITION/INFORMATION ON INGREDIENTS

Product contains: solvent, propellant, wax and additives.

Ingredient CAS-no. Content (%) Hazard symbol/R-phrases Remarks
Butane/propane 68475-59-2 30-60 F+;R12
Naphtha (petroleum), desulphurised heavy 64742-82-1 30-60 R10 Xn;R65 R66 R67 N;R51/53 Benzene < 0.1%


Key FB/FH/FM = Hazard code for fire/health/environment T+ = Very toxic T = Toxic C = Corrosive Xn = Harmful Xi = Irritant V = Moderately harmful IK = Not subject to labelling E = Explosive O = Oxidising F+ = Extremely flammable F = Highly flammable N = Dangerous for the environment


3. HAZARDS IDENTIFICATION

Extremely flammable. Do not spray toward open flame or incandescent material as the pressurised container may ignite. Exposure to a strong heat source may cause the aerosol to explode.

Adverse health effects Harmful by inhalation and in contact with skin. Vapours and spray may cause headaches, tiredness and nausea. Vapours/spray may irritate the respiratory system. Defats the skin. May irritate the eyes.
Adverse environmental effects This product contains volatile organic compounds that can contribute to the photochemical formation of ozone. The product contains a substance that is toxic to aquatic organisms and may cause long-term adverse effects in the aquatic environment.


4. FIRST AID MEASURES

Burns Rinse immediately with water. Remove while rinsing clothing/fabric that is not burnt on. Call an ambulance. Continue rinsing during transport.
Inhalation The person should rest in fresh air under supervision. In the event of discomfort, seek medical advice and take along this product data sheet.
Skin Take off immediately all contaminated clothing, and wash the effected skin with soap and water.
Eyes Rinse immediately with plenty of water for at least 15 minutes. Remove any contact lenses and keep the eyes wide open. If the irritation persists: Visit a hospital and present this product data sheet.
Ingestion Unlikely due to nature of packaging. Rinse the mouth immediately and drink plenty of water or milk. Keep the person under supervision. In case of discomfort seek medical advice and take along this product data sheet.


5. FIRE-FIGHTING MEASURES

Suitable extinguishing media Use a carbon dioxide or powder extinguisher. If exposed to heat, cool the aerosols with water and remove from the area of fire, if this is possible without entailing risk.
Specific hazards Exposure to a strong heat source may cause the aerosol to explode.


6. SPILLAGE/ACCIDENTAL DISCHARGE MEASURES

Personal precautions Do not breathe vapours or spray and avoid contact with skin and eyes. Smoking, naked flames and other sources of ignition forbidden. See point 8 regarding personal protective equipment.
Environmental precautions Do not dispose of aerosol containers in nature.
Methods for cleaning up Small spillages: Remove small spillages with absorbent material. Dispose of rags and the like that are contaminated with flammable fluids in a special fire-proof container. Large spillages: Remove with non-flammable absorbent material. Refer to point 13 for disposal measures.


7. HANDLING AND STORAGE

Advice for safe handling Observe good chemical hygiene. Do not breathe vapours and avoid contact with skin and eyes.
Technical measures Smoking, naked flames and other sources of ignition forbidden.
Technical information Mechanical ventilation may be necessary. Emergency sprinklers or other liberal supply of water must be present.
Storage instructions Follow directions for flammable liquids. Store large quantities and stocks as specified in national regulations for the storage of flammable liquids, etc.
Storage conditions Keep away from sources of heat and do not expose to high temperatures. Protect from direct sunlight.


8. EXPOSURE CONTROLS/PERSONAL PROTECTION

Technical measures Efficient ventilation must be provided. Limits must not be exceeded and the risk for breathing fumes and spray must be minimised.


Chemical identity Limit Type Ref.
Petroleum spirit, hexane 50ppm 180mg/m 3 NGV AFS 2000:3


Respiratory equipment In case of insufficient ventilation: Wear full-face mask with fresh air supply.
Hand protection If there is a risk of contact: Wear protective gloves. See glove manufacturer's recommendations for suitable gloves.
Eye protection If there is a risk of contact with eyes: Wear eye/face protection.
Skin protection: No special measures required.
Hygiene measures: Change soiled clothes.


9. PHYSICAL AND CHEMICAL PROPERTIES

Form/state Liquid Odour Of petrol
Colour Brown Solubility in water Insoluble
Relative density 0.704 g/cm 3 Vapour pressure (kPa) 3 bar at 20°C


10. STABILITY AND REACTIVITY

Stability Stable under specified storage conditions.
Conditions and material to avoid: Do not expose aerosols to high temperatures and protect from direct sunlight.
Hazardous decomposition products None under normal conditions.


11. TOXICOLOGICAL INFORMATION

Inhalation Vapours and spray may cause headaches, tiredness and nausea. Vapours/spray may irritate the respiratory system.
Skin Dries the skin. Prolonged or repeated contact may cause redness, itching and eczema/cracking.
Eyes Spray may cause irritation.
Ingestion Unlikely due to nature of packaging. May cause nausea, headache, dizziness and intoxication if swallowed.
Prolonged exposure Frequent repeated inhalation of even low concentrations can produce irritation, tiredness and memory loss and with time permanent damage to the nervous system, including the brain.


12. ECOLOGICAL INFORMATION

Mobility Propellant and solvent evaporate.
Degradability Degradability of product unknown.
Ecotoxicity This product contains volatile organic compounds that can contribute to the photochemical formation of ozone. The product contains a substance that is toxic to aquatic organisms and may cause long-term adverse effects in the aquatic environment.


13. DISPOSAL CONSIDERATIONS

Spilt product and waste should be disposed of in accordance with the regulations laid down by local authorities. Do no puncture or incinerate, even when empty.

Surplus Leave for controlled disposal, quoting EWC code 20 01 22.
Contaminated packaging Empty aerosol cans completely.


14. TRANSPORT INFORMATION

UN-no.: 1950 Transport name: AEROSOLS (Butane, Propane)


Sea (IMDG) Class: 2.1 EmS: 2-13 PG: - MFAG: 620 MP: P
Inland waterways To be handled locally.
Land (RID/ADR) Class: 2 Substance number: 5F Letter: -
Air (ICAO/IATA): Class: 2.1 PG: -
Other transport information Not classed as hazardous goods with regard to transport regulations.


15. REGULATORY INFORMATION

Labelling Extremely flammable.


R-phrases R12 Extremely flammable.
R66 Repeated exposure may cause skin dryness or cracking.
R67 Vapours may cause drowsiness and dizziness.
S-phases S23 Do not breathe vapour/spray.
S51 Use only in well-ventilated areas.
Other information Pressurised container. Protect from sunlight and temperatures above +50°C. Do not pierce or burn even after use. Do not spray against naked flame or any incandescent material. Keep away from sources of ignition - No smoking. Keep out of reach of children.
Specific Swedish regulations: The National Chemicals Inspectorate's regulations accompanying the regulations (KIFS 1994:12) on the classification and labelling of chemical products, KIFS 1997:5 and KIFS 1999:3 with amendments. The National Chemicals Inspectorate's Chemical Products and Biotechnical Organisms Regulations KIFS 1998:8, with amendments. Provisions of the Swedish National Board of Occupational Safety and Health on occupational exposure limits, AFS 2000:3. Commission Decision of 20 December 1993 establishing a list of wastes pursuant to Article 1(a) of Council Directive 75/442/EEC on waste (94/3/EC). List of wastes pursuant to Article 1(a) of Council Directive 75/442/EEC on waste (EUROPEAN WASTES CATALOGUE).


16. OTHER INFORMATION

The user must be given guidance as to appropriate working procedures and be acquainted with the contents of this product data sheet. The information contained in this safety data sheet is based on the information that was available at the time of preparation of this safety data sheet and is provided under the assumption that the product is used under the specified conditions and in accordance with the working methods specified on the packaging or in the relevant technical literature. All other use of this product, such as in conjunction with other products or in different processes, is undertaken at the risk of the user.

Issued 2000-10-04 by DANISH TOXICOLOGY CENTRE Kogle Allé 2 DK-2970 HØrsholm, Denmark. Tel: +45 45 76 20 55 Fax: +45 45 76 24 55



PRE-RELEASE