PRE-RELEASE
Checklist for replacement of control module, CIM
| ECU REPLACEMENT CHECKLIST SHEET |
THESE SHEETS MUST BE FILLED IN AND RETURNED WITH THE REPLACED PART.
IF THE SHEETS ARE MISSING OR NOT FILLED IN PROPERLY, WARRANTY CLAIM MAY BE REJECTED.
|
REPLACEMENT CHECKLIST
|
CIM |
Date:
|
|||||
| Column Integration Module | |||||||
| BACKGROUND INFORMATION: | PROBLEM AREA: | ||||||
| Dealer contact person: | Immobilizer: |
|
|||||
| SCL: |
|
||||||
| ISM: |
|
||||||
| Dealer contact telephone (incl international country code): | Locking: |
|
|||||
| Airbag: |
|
||||||
| VIN | Steering angle (SAS): |
|
|||||
| Km/miles: | P/I bus: |
|
|||||
| Customer Complaint: | Wiper/indicator lever: |
|
|||||
| Cruise control: |
|
||||||
| High beam/flash lever: | |||||||
| Noise: |
|
||||||
| Please get the part numbers below from the TECH2 | Calibration: | ||||||
| End model part no: | ESP: | ||||||
| Software part no: | Keyfob: | ||||||
| Base model part no: | Other: | ||||||
| Software module id #1 | (If other, please describe below) | ||||||
| Software module id #2 | |||||||
| Software module id #3 | |||||||
| ANALYSIS: | |||||||
| 1- Read out ALL DTCs in the vehicle and mark with an "X" in the list on page | YES NO | ||||||
| 2- Delete all DTCs present in the vehicle | YES NO | ||||||
| 3- Is it possible to repeat the Customer Complaint at the workshop? | YES NO | ||||||
| 4- Is the troubleshooting according to WIS performed? | YES NO | ||||||
| 5- Disconnect the unit, check all connectors and the wiring harness in the system concerned: | YES NO | ||||||
| 6- Is/are the DTCs still present after checking all above? | YES NO | ||||||
| (If YES, please describe below and DO NOT delete the DTCs if you are returning the replaced CIM to Saab). | |||||||
|
7- Are any other parts
in the car replaced in order to fix this actual problem?
If so, please describe below: |
YES NO | ||||||
|
|
|||||||
| DECISION: | |||||||
|
8- If CIM is replaced,
please describe the reason for CIM replacement/dealer analysis result:
NOTE! ATTACH THIS CHECK-LIST TO THE REPLACED PART(S). |
|||||||
| 9- Did the replacement(s) correct the issue? | YES NO | ||||||
THESE SHEETS MUST BE FILLED IN AND RETURNED WITH THE REPLACED PART.
IF THE SHEETS ARE MISSING OR NOT
FILLED IN PROPERLY, WARRANTY CLAIM MAY BE REJECTED.
DTC List
Mark with
a
X
in the left column if the DTC is active in the system.
|
CIM
|
|||
|
DTC
Active? |
DTC
|
Status
|
DESCRIPTION
|
| B0000 |
29
|
Wheel Speed RR, Wire from TCS/ESP, Short/Open | |
| B0000 |
59
|
+X Circuit to TCS/ESP, Open | |
| B0997 |
34
|
ISM, Internal Fault | |
| B0997 |
35
|
ISM, Internal Fault | |
| B0997 |
37
|
ISM, Internal Fault | |
| B0997 |
38
|
ISM, Internal Fault | |
| B1000 |
34
|
Control Module. Internal fault | |
| B1000 |
35
|
Control Module. Internal fault | |
| B1000 |
36
|
Control Module. Internal fault | |
| B1000 |
37
|
Control Module. Internal fault | |
| B1000 |
38
|
Control Module. Internal fault | |
| B1000 |
39
|
Control Module. Internal fault | |
| B1001 |
3A
|
Wrong Steering Wheel Installed | |
| B1001 |
41
|
Control Module Not Added | |
| B1001 |
66
|
Control Module Not Added | |
| B1001 |
67
|
Control Module Not Added | |
| B1001 |
41
|
Control Module Not Added | |
| B1001 |
66
|
Control Module Not Added | |
| B1001 |
67
|
Control Module Not Added | |
| B1016 |
0
|
Control Module Not Added | |
| B1020 |
30
|
SCL Internal Failure | |
| B1020 |
31
|
SCL Internal Failure | |
| B1020 |
32
|
SCL Internal Failure | |
| B1020 |
34
|
SCL Internal Failure | |
| B1020 |
35
|
SCL Internal Failure | |
| B1020 |
36
|
SCL Internal Failure | |
| B1020 |
37
|
SCL Internal Failure | |
| B1368 |
0
|
+15 Circuit, Short to B+ | |
| B1368 |
0F
|
+B Circuit, Short to B+ | |
| B1383 |
0
|
+X Circuit, Short to B+ | |
| B1440 |
0
|
+B Circuit from ISM, Open | |
| B1440 |
0F
|
+15 Circuit from ISM, Open | |
| B1440 |
57
|
Invalid Key Position | |
| B1440 |
58
|
Invalid Key Position | |
| B1440 |
71
|
ISM, Internal Fault | |
| B1445 |
1
|
Trigger Circuit CIM-SCL, Open/Short to B+ | |
| B1445 |
2
|
Trigger Circuit CIM-SCL, Short to Ground | |
| B2657 |
0
|
Illumination Steering Wheel Control circuit, Short to Ground | |
| B2810 |
2
|
Steering Wheel Control Circuit, Short to Ground | |
| B2810 |
4
|
Steering Wheel Control Circuit, Open | |
| B2810 |
0F
|
Steering Wheel Control Circuit, Value Incorrect | |
| B2911 |
0
|
ICM or CIM Not Added | |
| B2915 |
0
|
ICM Missing on Bus or Not Added | |
| B2919 |
0
|
ICM, Internal Failure | |
| B2955 |
0
|
ISM, Internal Fault | |
| B3055 |
0
|
No Transponder Detected at Key in | |
| B3056 |
0
|
No Transponders Programmed to CIM | |
| B3057 |
0
|
Control Module Not Added | |
| B3057 |
0F
|
SCL Not Added | |
| B3057 |
48
|
SCL Not Added | |
| B3060 |
0
|
Unknown Transponder Detected at Key in | |
| B3109 |
0
|
Remote Control 1, Low Battery | |
| B3110 |
0
|
Remote Control 2, Low Battery | |
| B3111 |
0
|
Remote Control 3, Low Battery | |
| B3112 |
0
|
Remote Control 4, Low Battery | |
| B3113 |
0
|
Remote Control 5, Low Battery | |
| B3114 |
0
|
Remote Control 1, Wrong Code (May Set when Used out of Range) | |
| B3115 |
0
|
Remote Control 2, Wrong Code (May Set when Used out of Range) | |
| B3116 |
0
|
Remote Control 3, Wrong Code (May Set when Used out of Range) | |
| B3117 |
0
|
Remote Control 4, Wrong Code (May Set when Used out of Range) | |
| B3118 |
0
|
Remote Control 5, Wrong Code (May Set when Used out of Range) | |
| B3498 |
0F
|
- | |
| B3598 |
2
|
Cruise Control Switch Circuit, Short to Ground | |
| B3598 |
4
|
Cruise Control Switch Circuit, Open | |
| B3598 |
0F
|
Cruise Control Switch Circuit, Value Incorrect | |
| B3622 |
5
|
Steering Wheel Control, Horn, Open/Short to B+ | |
| B3622 |
0F
|
Steering Wheel Control, Horn, Value Incorrect | |
| B3622 |
59
|
Steering Wheel Control, Stuck | |
| B3700 |
2
|
Stalk Switch Wiper Interval Circuit, Short to Ground | |
| B3700 |
4
|
Stalk Switch Wiper Interval Circuit, Open | |
| B3700 |
0F
|
Stalk Switch Wiper Interval Circuit, Value Incorrect | |
| B3800 |
2
|
Stalk Switch Turn Indicators Circuit, Short to Ground | |
| B3806 |
5
|
Stalk Switch Flash to Pass Circuit, Open/Short to B+ | |
| B3922 |
0
|
Stalk Switch Wiper Front Circuit, Malfunction | |
| B3924 |
0
|
MIU or CIM Not Added | |
| B3925 |
0
|
BCM or CIM Not Added | |
| B3926 |
0
|
- | |
| B3927 |
0
|
PDM or CIM Not Added | |
| B3935 |
0
|
Malfunctioning Transponder Detected at Key in
|
|
| B3936 |
0
|
Stalk Switch Wiper Rear Circuit, Malfunction
|
|
| B3943 |
48
|
SCL Not Added
|
|
| B3945 |
0
|
K-line SCL-CIM, Signal Faulty
|
|
| B3946 |
0
|
SCL Not Added
|
|
| B3947 |
0
|
CIM or SCL Not Added
|
|
| B3948 |
0
|
Information DTC: Steering Lock System, Critical Failure
|
|
| B3948 |
0F
|
Information DTC: Steering Lock System, Non Safety Critical
Failure
|
|
| B3977 |
0
|
Control Module Not Added
|
|
| B3978 |
0
|
MIU Missing on Bus or Not Added
|
|
| B3979 |
0
|
BCM Missing on Bus or Not Added
|
|
| B3980 |
0
|
-
|
|
| B3981 |
0
|
PDM Missing on Bus or Not Added
|
|
| B3984 |
0
|
MIU, Internal Failure
|
|
| B3985 |
0
|
BCM, Internal Failure
|
|
| B3987 |
0
|
PDM, Internal Failure
|
|
| C0253 |
0
|
Steering Angle Sensor, Not Calibrated
|
|
| C0460 |
0
|
Steering Angle Sensor, Not Calibrated or Faulty
|
|
| C0490 |
1
|
ISM-SCL, Unsecure Locking bolt Circuit, Short to B+
|
|
| C0490 |
6
|
ISM-SCL, Unsecure Locking bolt Circuit, Open/Short to
Ground
|
|
| C0544 |
0
|
Steering Angle Sensor, Internal Failure
|
|
| C0547 |
1
|
SCL-ISM, Unlocked & Secured Circuit, Short to B+
|
|
| C0547 |
2
|
SCL-ISM, Unlocked & Secured Circuit, Short to Ground
|
|
| C0547 |
3
|
SCL-ISM, Unlocked & Secured Circuit, Open
|
|
| C0548 |
1
|
SCL Internal Failure
|
|
| C0548 |
4
|
SCL Internal Failure
|
|
| C0548 |
6
|
SCL Internal Failure
|
|
| C0548 |
8
|
SCL Internal Failure
|
|
| U1500 |
1
|
K-line CIM-SCL, Short to Ground/B+
|
|
| U1500 |
0F
|
K-line CIM-SCL, Open
|
|
| U1500 |
38
|
Invalid Response from SCL
|
|
| U1501 |
1
|
K-line CIM-ISM, Short to Ground/B+
|
|
| U1501 |
0F
|
K-line CIM-ISM, Open
|
|
| U2100 |
0F
|
CIM was Missing on I-Bus
|
|
| U2100 |
0
|
CIM was Missing on P-Bus
|
|
| DTCs RELATED TO OTHER UNIT(S) | ||
|
DTC
|
DESCRIPTION
|
|
