PRE-RELEASE
Engine bay electrical centre 342 (UEC)
| Engine bay electrical centre 342 (UEC) |
| Location |
The electrical centre is located between the battery and the left front wing.
| Main task |
Act as the electrical centre for the front of the car and handle some parts of the logic for the front lighting as well as the visibility and signal systems.
Distributes current from the battery to the other electrical centres.
The electrical centre contains the transport fuse (fuse 37).
| Type |
Electrical centre with relays, maxi and micro-fuses and integrated control module for logic operations.
| Connect |
The fuse box is connected to the battery and to grounding points G30A, G31 and G33S. The electrical centre is connected via three switches in its base to the engine harness, front harness and main wiring harness.
Power supply circuit for +30
Power supply circuit for +15
The engine harness is connected via switch M
The main wiring harness is connected via switch B
| Fuses |
The electrical centre can contain a greater number of fuses than those listed below. In such cases, these are not connected to a wiring harness.
| No | Amp | Type | Function | Illustration |
| 1 | 30 | +30 | Z19 (EDC16) via main relay 229: ECD16 control module (595B) Glow plug control module (596) Boost pressure control valve (179a) Heating element, oxygen sensor (271) Actuator, swirl throttle (403) Actuator, throttle body (604) Solenoid valve, EGR (606) |
|
| 2 | 10 | +30 | TCM (502a/b) Trionic T8 control module (589A) Control module, ME9 (608B) |
|
| 3 | 20 | +30 | Horn |
|
| 4 | 10 | +15 | TCM, AF 40 (502b) Battery disconnect switch (700) B207 (T8): Trionic T8 control module (589A) B284 (ME9): Control module, ME9, switch B (608B) Mass air flow sensor (205) Z19 (EDC16): ECD16 control module (595B) Module, mass air flow sensor (686) Water level sensor, fuel filter (692) Module, power steering unit (745) Switch, coupling, immobiliser (411) |
|
| 5 | -- | -- | ||
| 6 | 10 | +30 | TCM, FA 57 (502a) Immobilizer switch, automatic (77) Gear selector, automatic (245) Immobilizer switch (411) |
|
| 7 | 7.5 | +15 | Control module, headlight, left (628FL) |
|
| 8 | 5 | +15 | Vacuum pump unit (459) Control module EDC16 Diesel (595B) |
|
| 9 | 10 | +15 | Control module, AFL |
|
| 10 | -- | |||
| 11 | -- | |||
| 12 | 10 | +30 | Washer fluid pump, rear window (63c) |
|
| 13 | 10 | +30 | EDC16: A/C compressor (170) |
|
| 14 | +30 | Battery sensor (343) |
|
|
| 15 | 30 | +30 | Motor, high-pressure headlight washer pump (668) |
|
| 16 | 30 | Lighting, left front: Side direction indicators, dipped beam, fog light Lighting, right front : Position lamp, direction indicator, side direction indicator, main beam |
|
|
| 17 | 30 | Windscreen wiper motor, low-speed Starter motor (4) |
|
|
| 18 | 30 | Windscreen wiper motor, high-speed |
|
|
| 19 | 20 | +30 | Parking heater, diesel (597) Connection, accessories (711) |
|
| 20 | 10 | +15 | Motors, manual headlamp levelling (280) AHL control module (664) Control module, headlight, right (682FR) |
|
| 21 | Control module EDC16 Diesel (595B) | |||
| 22 | 30 | +30 | Washer fluid pump, windscreen (63b) |
|
| 23 | -- | |||
| 24 | 20 | +30 | Auxiliary lamp |
|
| 25 | 20 | +30 | Front amplifier (354F) |
|
| 26 | 30 | +30 | Lighting, left front: direction indicator, position lamp, main beam Lighting, right front: dipped beam, fog light |
|
| 27 | 60 maxi 20 maxi | +30 | B207 (T8): Main fuse for fuse box 727 Z19 (EDC16): fuel pump (323) Switch, clutch, immobiliser (411) |
|
| 28 | 40 maxi | +30 | Control module, TCS/ESP (382/671) |
|
| 29 | 60 maxi | +30 | Main fuse 2 for rear electrical centre | |
| 30 | 60 maxi | +30 | Main fuse 1 for dashboard electrical centre | |
| 31 | 40 maxi | +30 | Starter motor solenoid via relay 517 |
|
| 32 | 60 maxi | +30 | Main fuse 2 for dashboard electrical centre | |
| 33 | 40 maxi | +30 | Control module, TCS/ESP (382/671) |
|
| 34 | 60 maxi | +30 | Main fuse 1 for rear electrical centre | |
| 35 | 30 maxi | +30 | B207: Radiator fan B248: Vacuum pump unit |
|
| 36 | 20 maxi | +30 | B207: Radiator fan EDC16: Heating element, fuel filter |
|
| 37 | 60 maxi | +30 | Transport lock. Main fuse 3 for rear electrical centre |
| Relays |
The electrical centre can contain a greater number of relays than those listed below. In such cases, these are not connected to a wiring harness.
| Location | No | Description | Illustration | Diagram |
| R1 | 432b | Relay, washer fluid pump, windscreen |
|
|
| R2 | 156 | Relay, A/C compressor (Simtec and EDC16) |
|
EDC16 |
| R3 | -- | |||
| R4 | 641 | Relay, diesel preheating |
|
|
| R5 | 675 | Relay, extra lights |
|
|
| R6 | 68 | Horn relay |
|
|
| R7 | 229 | Main relay, engine management system (Simtec and EDC16) |
|
|
| R8 | 517 | Relay, +50 |
|
B207 B284 Z19 |
| R9 | 83 | Windscreen wiper relay |
|
|
| R10 | 432c | Relay, washer fluid pump, rear window |
|
|
| R11 | 757F | Relay, +15, UEC |
|
|
| R12 | 709 | Relay, windscreen wiper, full/half speed |
|
|
| R13 | -- | |||
| R14 | 667 | Relay, washer fluid pump, high-pressure, headlamp |
|
|
| R15 | -- | |||
| R16 | -- |
