PRE-RELEASE
Engine management system, EDC16 (Part 4/4)
| Engine management system, EDC16 (Part 4/4) |
| List of components |
| No. | Name Location | Illustration |
|
Components |
||
|
22a
|
Fuse box, dashboard
on end of dashboard next to driver's door |
|
|
229
|
Main relay, engine control system,
on the main relay board in the dashboard |
|
|
398a
|
Glow plug, cylinder 1,
in the rear section of the cylinder head |
|
|
398b
|
Glow plug, cylinder 2,
in the rear section of the cylinder head |
|
|
398c
|
Glow plug, cylinder 3,
in the rear section of the cylinder head |
|
|
398d
|
Glow plug, cylinder 4,
in the rear section of the cylinder head |
|
|
595A
|
Control module, 4-cyl diesel EDC16, switch A,
in space (cabin side) in front of windscreen on passenger side |
|
|
595B
|
Control module, 4-cyl diesel EDC16, switch B,
in space (cabin side) in front of windscreen on passenger side |
|
|
596
|
Glow plug control module,
between mass air flow sensor and power steering fluid reservoir |
|
|
602F
|
Temperature sensor, exhaust, front,
component: in inlet to first catalytic converter connector: on bracket beside the turbo |
|
|
602R
|
Temperature sensor, exhaust, rear,
component: in front edge on rear catalytic converter connector: on bulkhead partition below coolant reservoir |
|
|
606
|
EGR control valve,
on the front of the throttle housing |
|
|
744
|
Pressure sensor, exhaust system,
on bulkhead partition below coolant reservoir |
|
|
11-pin connector |
||
|
H11-1
|
On RH side of engine by fuel pump
|
|
|
24-pin connector |
||
|
H24-1
|
Grey connector in middle of bulkhead partition (engine compartment side)
|
|
|
H24-2
|
Black connector in middle of bulkhead partition (engine compartment side)
|
|
|
33-pin connector |
||
|
H33-1
|
At the relay box in the dashboard
|
|
|
Crimp connectors |
||
|
J55
|
LHD:
Approx. 125 mm from branching point DICE control module towards the main relay board
RHD: Approx. 430 mm from branching of grounding point G42 towards DICE control module |
|
|
J169
|
In grommet to dashboard main fuse box
|
|
|
J212
|
Approx. 360 mm from branching of front load angle sensor towards right-hand headlamp l
|
|
|
J229
|
Approx. 240 mm from connector H33-1
|
|
|
J234
|
Approx. 240 mm from connector H33-1
|
|
|
J265
|
Approx. 100 mm from branching of camshaft position sensor towards intake air sensor
|
|
|
J266
|
Approx. 100 mm from branching of camshaft position sensor towards intake air sensor
|
|
|
J267
|
Approx. 50 mm from connector A to diesel engine control module
|
|
|
Grounding points |
||
|
G30
|
In engine bay on side panel in front of LH wheel housing
|
|
|
G40
|
In cabin on LH side of knee member
|
|
|
G42
|
In cabin on RH side of knee member
|
|
