SAAB WIS ONLINE

PRE-RELEASE

Headlamp Leveling Malfunction (TR6)

Headlamp Leveling Malfunction (TR6)

Diagnostic Instructions


Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure.

Review Strategy Based Diagnosis for an overview of the diagnostic approach.

Diagnostic Procedure Instructions has overviews of all diagnostic categories.


Diagnostic Fault Information

Circuit Short to Ground Open/High Resistance Short to Voltage Signal Performance
Ignition Headlamp Switch

1

1

-

-

Ignition Left Headlamp

1

2

-

-

Ignition Right Headlamp

1

3

-

-

Left Headlamp Leveling Control

1

2

1

-

Right Headlamp Leveling Control

1

3

1

-

Left Headlamp Ground

-

2

-

-

Right Headlamp Ground

-

3

-

-

1. All Headlamp Leveling Actuator Malfunction

2. Left Headlamp Leveling Actuator Malfunction

3. Right Headlamp Leveling Actuator Malfunction



Circuit/System Description

Each headlamp assembly contains a headlamp leveling motor that is controlled by the headlight switch. The headlight switch is a resistance ladder switch and wired to each headlamp leveling motor. With the ignition in ON position the headlight switch and each headlamp leveling motor is applied to B+. Each headlamp leveling motor is permanently grounded.

Reference Information

Schematic Reference

Headlights/Daytime Running Lights (DRL) Schematics

Connector End View Reference

Component Connector End Views

Description and Operation

Exterior Lighting Systems Description and Operation

Electrical Information Reference


Circuit Testing

Connector Repairs

Testing for Intermittent Conditions and Poor Connections

Wiring Repairs


Scan Tool Reference

Control Module References for information on diagnostic tools

Circuit/System Verification

Ignition ON, cycle the headlamp leveling switch in each position while observing both headlamps. Both headlamps should operate to the appropriate position when commanded.

Circuit/System Testing


1. Ignition OFF, disconnect the harness connector at the appropriate inoperative headlamp assembly.

2. Test for less than 5 Ω between the ground circuit terminal 7 and ground.

3. If greater than the specified range, test the ground circuit for an open/high resistance.

4. Ignition ON, verify a test lamp illuminates between the ignition circuit terminal 6 and ground. The test lamp should turn ON.

5. If the test lamp does not illuminate, test the ignition circuit for a short to ground or an open/high resistance.

6. Ignition OFF, disconnect the harness connector at the S30 Headlamp Switch.

7. Ignition ON, connect a test lamp between the ignition circuit terminal 9 and ground. The test lamp should turn ON.

8. If the test lamp does not illuminate, test the ignition circuit for a short to ground or an open/high resistance.

9. Test for less than 0.3 V between the signal circuit terminal 10 and ground.

10. If greater than the specified range, test the signal circuit for a short to voltage.

11. Ignition OFF, install a 3 A fused jumper wire between the signal circuit terminal 10 and B+. Check fuse from jumper wire.

12. If the fuse is blown, test the signal circuit for a short to ground.

13. Disconnect the 3 A fused jumper wire, test for less than 5 Ω between the signal circuit terminal 10 at the S30 Headlamp Switch and the control circuit terminal 8 at the appropriate headlamp assembly.

14. If greater than the specified range, test the signal circuit for an open/high resistance.

15. Reconnect the harness connector at the S30 Headlamp Switch.

16. Ignition ON, test for 2.5-7 V between the control circuit terminal 8 at the appropriate headlamp assembly and ground. Move the switch for headlamp level control between all positions. The voltage should change with each position.

17. If the voltage does not change, test or replace the S30 Headlamp Switch.

18. If all circuits test normal, replace the appropriate headlamp assembly.


Component Testing


Static Test

1. Ignition OFF, disconnect the harness connector at the S30 Headlamp Switch.

2. Switch the headlamp leveling switch in position 0. Test for 2.2-2.4 kΩ between the ignition circuit terminal 9 and the signal terminal 10.

3. If not within the specified range replace the S30 Headlamp Switch.

4. Switch the headlamp leveling switch in position 1. Test for 1.9-2.2 kΩ between the ignition circuit terminal 9 and the signal terminal 10.

5. If not within the specified range replace the S30 Headlamp Switch.

6. Switch the headlamp leveling switch in position 2. Test for 1.7-2.1 kΩ between the ignition circuit terminal 9 and the signal terminal 10.

7. If not within the specified range replace the S30 Headlamp Switch.

8. Switch the headlamp leveling switch in position 3. Test for 1.4-1.7 kΩ between the ignition circuit terminal 9 and the signal terminal 10.

9. If not within the specified range replace the S30 Headlamp Switch.


Repair Instructions

Perform the Diagnostic Repair Verification after completing the diagnostic procedure.


Headlamp Switch Replacement

Headlamp Replacement


PRE-RELEASE